|Topic Review (Newest First)|
|01-05-2020 07:29 PM|
All seems to be good now that I have changed the coolant.
I've noticed the fan is working fine too. It seems to start up after the engine has warmed up slightly (2 bars).
Will just have to keep at eye on the fluid levels. It has seemed to have dropped a little already. This could be normal as I did overfill it a tiny bit.
|01-04-2020 03:15 PM|
Originally Posted by Rykers View Post
|01-03-2020 11:08 PM|
Now that I've filled the reservoir on mine to the max, it should be easy to tell if it declines or evaporates. Stay tuned.
Then again, the forecast here is for rain for 10 days so I gotta wait 😕
|01-03-2020 10:58 PM|
|Crimson Apple||Yes, every 1000 miles and evap small amount. My car and moto does the same thing. If you pour to the maximum line and no air is in the system it should stay at the line for around 3000 miles also depends your weather and riding style. If some how you had too keep pouring and pouring and pouring every day or every other day you need check your oil for milky content and or leak.|
|01-03-2020 10:10 PM|
Originally Posted by 2wheels4fun View Post
Doesn't appear to be a simple way to test the fan other than this.
|01-03-2020 10:08 PM|
Originally Posted by Crimson Apple View Post
This is on the V300. Do you know if the coolant could just "evaporate" over time?
|01-03-2020 10:03 PM|
So I just pulled it all apart and did a coolant change.
You're right about the coolant being hard to see between the fairings, as once I had the fairings off I could see there was actually a small amount of fluid in the reservoir (still below the low level).
I saw online that the bike should hold approx 1.5 litres of coolant combined in the radiator/cooling system and the reservoir. I only got about half a litre out of the drain plug.. so it was definitely low.
I haven't noticed any leaking whatsoever, and all the hoses, joints and plugs were clean and dry. This is my first coolant service as the new owner so I'm not sure where the rest of the coolant went. As far as I know unless you have a leak it should never drop in level?
Refilled with engine ice and appears to be fine so far, will just have to keep and eye on it.
|01-03-2020 09:57 PM|
|Crimson Apple||Called it... I knew...|
|01-03-2020 09:34 PM|
|whisperquiet||The coolant overflow tank level is very difficult to see and the only way I have found to properly view it is by backlighting it with a flashlight from the fork side of the fairing. FYI, I live in hot, humid southern Illinois (in summer) and the X 300 will heat up quick while stopped or while riding very slowly. It should drop pretty fast as you increase speed and get some airflow through the radiator,|
|01-03-2020 06:52 PM|
Funny that you mention this...I was checking my rad reservoir and couldn't see any coolant either.
I've never had an overheating issue - mind you I'm commuting and at 5:30 AM here it's just above freezing. Suffice to say it's always cool and the bike runs at 2 bars, sometimes 3.
So I still think I might have coolant leak though there's never been a spot on garage floor - neither home nor office.
So I bought some coolant and promptly overfilled till it was spilling on the floor. Then I went for a ride to heat things up and watched this drip drip drip on the ground - removed the ride side lower cover and lo and behold, dripping out the overflow tube like its supposed to.
I'm not the best mechanic...
|01-03-2020 05:08 PM|
Probably should of checked this first.. but turns out there was pretty much no coolant in the reservoir at all 😱.
Going to do a flush and leak test, will then fill up with engine ice, thanks for the tip.
|01-03-2020 08:51 AM|
The fan should have come on and lowered the temp while sitting at a light.
You are going to feel the heat because you have an engine between your legs. When moving though the tops of your legs should feel hotter from the sun than the inside of your thighs from the bike.
If the cooling system is operating correctly, you could change to "Engine Ice" which is supposed to be a more efficient heat transfer fluid. I switched to "Engine Ice" in my liquid cooled bikes at the first coolant service interval.
|01-03-2020 06:17 AM|
|2wheels4fun||Also check if fan was on when hit top bar. I think it comes on at the second from top bar.|
|01-03-2020 06:08 AM|
|Crimson Apple||Check if you got an oil leak or a coolant leak. I assume you have the V300.|
|01-03-2020 03:40 AM|
Overheating issues, is this considered normal?
I was out riding today and the temperature was around 33°c (about 90°f) and my bike began heating up so much is was burning the inside of my thighs.
This was after sitting at the lights, occasionally moving at slow speeds for around 5 minutes.
I checked the engine temp on the display and it was full bars to the top!
I was getting a bit concerned but once I started moving it cooled down by 2 bars.
Tank still felt very hot, but was bearable and got me home okay...
Is this considered normal or should I change the coolant or maybe have the coolant system checked out?